Page Banner

United States Department of Agriculture

Agricultural Research Service

Title: Dust Collection Efficiency of over-Sized Cotton Gin Cyclones

Authors
item Baker, Kevin
item Funk, Paul
item Hughs, Sidney

Submitted to: National Cotton Council Beltwide Cotton Conference
Publication Type: Proceedings
Publication Acceptance Date: January 8, 2002
Publication Date: June 27, 2002
Citation: BAKER, K.D., FUNK, P.A., HUGHS, S.E. DUST COLLECTION EFFICIENCY OF OVER-SIZED COTTON GIN CYCLONES. NATIONAL COTTON COUNCIL BELTWIDE COTTON CONFERENCE. 2002. 3 p.

Interpretive Summary: Results from this research indicate that over-sized cyclones create much less (about 72% less) back pressure yet have nearly the same effectiveness in removing dust from the air as a standard-sized cyclone. This is beneficial because dust emissions from cotton gins can lead to air quality problems and gin owners should invest in equipment to reduce the amount of dust that is emitted from their gin in order to comply with local clean air standards. Depressed agricultural prices limit the amount of capital that can be invested in devices to remove dust from the air. Cyclones are one of the least expensive air cleaning devices that can be used in a gin; however, they increase the back pressure on fans. Sometimes fans must be replaced to overcome the additional back pressure from the newly installed cyclone. By installing an over-sized cyclone instead of a standard-sized cyclone in situations where the additional back pressure would be a problem, the investment cost is reduced because fan replacement is not needed, yet air cleanliness is not compromised. Results are being disseminated to gin owners and operators as well as to state and local air pollution control boards.

Technical Abstract: Three model cyclones were tested at four trash loading rates. Cyclone collection efficiency for over-sized cyclones was slightly less than the efficiency of a standard-sized cyclone, averaging 98.63 and 98.42%, respectively. Cyclone collection efficiency increased as trash loading rate increased, with average values ranging from 97.93% at a trash loading rate of 0.88 grain/ft3 (2 g/m3) to an average of 98.95% at a trash loading rate of 7.0 grain/ft3 (16 g/m3). Cyclone pressure drops for over-sized cyclones were much less than pressure drops for standard-sized cyclones, with the pressure drop in an over-sized cyclone averaging 28% of the value for pressure drop in a standard-sized cyclone. The authors concluded that, with their lower pressure drop, over-sized cyclones are more compatible than standard-sized cyclones on airflow systems that use axial-flow fans. Collection efficiency of over-sized cyclones was just slightly less than that of standard-sized cyclones.

Last Modified: 7/25/2014
Footer Content Back to Top of Page