Page Banner

United States Department of Agriculture

Agricultural Research Service

Research Project: NEW TECHNOLOGIES TO IMPROVE AND ASSESS MEAT QUALITY IN MUSCLE FOODS Title: Effect of rapid thawing on the meat quality attributes of beef strip loin steaks

Authors
item Eastridge, Janet
item Bowker, Brian

Submitted to: Journal of Food Science
Publication Type: Peer Reviewed Journal
Publication Acceptance Date: December 6, 2010
Publication Date: March 1, 2011
Citation: Eastridge, J.S., Bowker, B.C. 2011. Effect of rapid thawing on the meat quality attributes of beef strip loin steaks. Journal of Food Science. 76(2):S156-S162.

Interpretive Summary: Freezing rate and frozen storage effects on meat quality have been well documented; however, there is comparatively little information on the meat quality effects of rapid thawing within food safety guidelines. This study demonstrates that beef strip loin steaks can be rapidly thawed in as little as 11 minutes without affecting texture or cooking yield while reducing thaw drip loss. Thus, rapid thawing may enhance the apparent juiciness of steaks for consumers and provide an effective method for maintaining consistent control of experimental conditions for researchers.

Technical Abstract: The objective of this study was to determine the meat quality effects of rapidly thawing steaks in a water bath. Frozen beef strip loins (n = 24) were cut into steaks sequentially from the rib end and identified by anatomical location (anterior, middle, posterior) within the loin. Within location, steaks were randomly assigned to conventional (C; 18 - 24 h at 4 °C) or rapid thawing methods. Rapid thawing methods, fast (F; 20 min at 20 °C) or very fast (V; 11 min at 39 °C), were conducted in a circulating water bath. The physical, thawing, cooking, color, and texture characteristics of each steak were recorded. Data were analyzed as a randomized complete block design with a 3 thawing treatments × 3 locations factorial analysis with loin as a block. No location by thawing method interaction was detected (P > 0.05) for any of the measured variables. Compared to C steaks, rapidly thawed steaks (F and V) exhibited lower thaw drip loss (P < 0.0001) and higher a* values (P < 0.0001). Thawing treatment did not significantly influence L*, b*, cook yield, or WBSF. Steaks from the posterior end had a higher (P < 0.001) surface: volume ratio which may have contributed to the higher thaw loss (P < 0.001), longer cooking time (P < 0.001), lower cooking yield, and higher shear force (P < 0.02) compared to steaks from the anterior and middle portions of the loins. These data suggest that beef steaks taken from the entire length of the strip loin can be rapidly thawed in a water bath following food safety guidelines with minimal impact on meat quality attributes.

Last Modified: 7/28/2014
Footer Content Back to Top of Page