Skip to main content
ARS Home » Southeast Area » Florence, South Carolina » Coastal Plain Soil, Water and Plant Conservation Research » Research » Publications at this Location » Publication #197673
Title: SIMULTANEOUS SEPARATION OF PHOSPHORUS SLUDGE AND MANURE SOLIDS WITH POLYMERS

Author
item CRUZ GARCIA, MARIA - AG TECH INST CASTILLA, SP
item Vanotti, Matias
item Szogi, Ariel

Submitted to: Transactions of the ASABE
Publication Type: Peer Reviewed Journal
Publication Acceptance Date: 10/19/2007
Publication Date: 1/21/2008
Citation: Garcia, M.C., Vanotti, M.B., Szogi, A.A. 2008. Simultaneous separation of phosphorus sludge and manure solids with polymers. Transactions of the ASABE 50(6):2205-2215.

Interpretive Summary: In order to simplify an environmentally superior wastewater treatment system without lagoon for liquid swine manure and reduce installation and operation costs, we considered combining two contrasting slurries, flushed swine manure (SM) and alkaline phosphorus sludge (PS), with the goals of flocculating and dewatering the materials in a simultaneous operation that uses one common dewatering equipment and produces only one stream of solids. We discovered that this concept of simultaneous separation is technically feasible. Although SM and PS solids have contrasting chemical characteristics, they were efficiently (>90%) separated using a single polymer application of cationic PAM. The simultaneous separation process did not increase the amount of PAM that would normally be used to effectively treat SM alone even when the new mixture contained 43% more suspended solids and 94% more phosphorus as a result of PS addition. The water quality of the treated liquid was improved, and the P content of the separated solids was significantly increased, which makes the material more desirable as a fertilizer. Compared with a typical situation where two dewatering units are used to separate two specific sludges, the simultaneous separation process is more efficient in terms of polymer use and equipment needs. Thus, its implementation can significantly reduce both installation and operational cost of treatment.

Technical Abstract: In this work we describe improvement of a treatment system without lagoon through implementation of a concept of simultaneous separation of solids. The original system consisted of three basic processes in series: solid-liquid separation of raw swine manure (SM) using cationic polyacrylamide (PAM), subsequent treatment of liquid through nitrification-denitrification, and a soluble P removal unit. The P-removal unit used hydrated lime to precipitate P and anionic PAM to enhance dewatering of the P-rich sludge (PS). Our objectives were to evaluate if it is technically feasible to flocculate and dewater both the PS and SM in a simultaneous operation, using the same dewatering equipment and producing only one stream of solids. The simultaneous separation concept was tested in a laboratory prototype using PS and SM materials from a first-generation version of the system without lagoon installed in a swine farm in North Carolina. Compared with SM, the PS material had a higher pH (10.1 vs. 7.5), and about 5 times more total suspended solids (TSS) (29.5 vs. 5.7 g/L), and nine more times the total P (2.7 vs. 0.3 g/L). We found that the PS remained as a solid when mixed with SM, and all the solids were efficiently separated (>90%) using a single polymer application (cationic PAM). The simultaneous separation process did not increase the amount of PAM that would normally be used to effectively treat SM alone. The same dosage of PAM (60 mg/L) was effective even when the mixture contained 43% more TSS and 94% more TP as a result of PS addition (up to 150 mL/L). PAM effectiveness in terms of TSS or TP increased with the simultaneous separation process, from 108 to 160 g TSS/g/PAM, and from 4.7 to 11.4 g TP/g/PAM. Mass removal efficiencies at the higher PS rate were 96.8% for TSS and 94.7% for TP. Water quality of the treated liquid was also improved, and the P content of the separated solids was significantly increased, from 9.5 to 16.9% P2O5. Our results indicate that simultaneous separation of two contrasting sludges with PAM is technically feasible, and that the combined separation process is more efficient in terms of polymer use and equipment needs compared with a situation where two dewatering units are used to separate the same amount of solids. Thus, its implementation can reduce installation and operational cost of the overall treatment system.