Page Banner

United States Department of Agriculture

Agricultural Research Service

Research Project: DIETARY FACTORS AFFECTING THE FEEDING VALUE OF CORN-BASED DISTILLER'S GRAINS FED TO CATTLE

Location: Renewable Energy and Manure Management Research

2011 Annual Report


1a.Objectives (from AD-416)
The objectives of this cooperative research project are to (1) assess the effects of the wet cake to solubles ratio of distiller's grains with solubles on the performance and carcass characteristics of finishing beef cattle, (2) assess the effects of the wet cake to solubles ratio of distiller's grains on potential nitrogen and phosphorus losses from feedyards, and (3) assess the effects of the extent of dietary corn processing and wet distiller's grain concentration on energy metabolism of beef cattle.


1b.Approach (from AD-416)
The feeding value of wet distiller's grains with solubles for finishing beef cattle can be affected by the ratio of distiller's grain (i.e. wet cake) and solubles. However, to our knowledge, no research studies have been conducted to evaluate the effects of the cake:solubles ratio on animal performance when diets are based on steam flaked corn. These comparisons needed by nutritionists and feedlot managers so they can value different sources of distiller's grains. We propose a comparison involving combining the grains and solubles from a corn-ethanol plant at different ratios. In a feeding trial, 36 pens of beef steers (approximately 432 head with an average starting body weight of 650 lbs) will be fed one of four experimental diets with nine pens (12 head per pen) per treatment. Wet cake and solubles will be purchased separately from an ethanol plant in the area and will be mixed in the desired ratios at the WTAMU experimental feedlot. Experimental diets will include:.
1)a control diet based on steam-flaked corn (SFC) with no distiller's grains or distiller's solubles,.
2)a diet with 20% wet corn distiller's grains (i.e., wet cake) plus no condensed corn solubles,.
3)a diet with 15% wet cake plus 5% condensed corn solubles, and.
4)a diet with 10% wet cake plus 10% condensed corn solubles. Steers will be fed in open lot pens and slaughtered when backfat thickness is visually estimated to be 0.5 inches. Dry matter intake and averaged daily gain will be measured. Standard carcass measurements will be collected at slaughter. ARS personnel will obtain samples of diets, feed ingredients, fresh feces, and air dried manure for determination of nutrient excretion, and nitrogen volatilization losses.

In a calorimetry study, six steers will be used in a 6 x 6 Latin square design. Treatments will be in a 2 x 3 factorial with 2 degrees of corn steam flaking (bushel weights of 24 or 28 lbs.) and three concentrations of wet distiller's grains (0, 15 or 30% of diet dry matter). Using open circuit, indirect respiration calorimeters, carbon dioxide and methane production and oxygen consumption of individual steers will be determined. Energy digestibility, heat production, energy retention, and dietary energy values will be determined.


3.Progress Report

A portion of the cattle for this study are currently being grown on a receiving study that will end in August 2011. These cattle will be allowed a period of washout of approximately 28 days from previous treatments before being randomized for this study. The remaining cattle will be purchased from typical sources and enrolled in the study. Treatments will include a control ration without distiller's byproducts, 15% corn distiller's grains with an additional 5% corn distiller's soluble, 15% sorghum distiller's grains with 5% sorghum distiller's soluble, and 20% sorghum distiller's grains. The study will involve nine pen replicates, with each pen containing up to ten animals. The ADODR and lead investigators are in regular contact via e-mail, phone, and face-to-face contacts. The ADODR monitors cooperator expenditure of funds through semi-annual reports from the cooperator and via contacts with the lead investigator.


Last Modified: 9/23/2014
Footer Content Back to Top of Page